Century CW2500 Bedienungshandbuch

45399A OWNER`S MANUAL CW2500 Insert US ENVIRONMENTAL PROTECTION AGENCY PHASE II CERTIFIED WOOD INSERTS Verified and tested following ULC S

9 2.3 Safety Information NOTE: This appliance is not recommended for use in a home if an occupant has any respiratory or any other related problems.

10 2.4 Installation Instructions 1. Inspect the fireplace according to the safety information and fireplace requirements and have it cleaned and/or

11 2.5 Air control plate, faceplate and fan Assembly Instructions 1. Place the faceplate panels with the finished side down on a flat, soft, non-ab

12 Section 3.0 Operation 3.1 Safety Information 1. This insert is designed for safe operation WHEN BURNING CORDWOOD ONLY. Altering or modifying

13 overheat the chimney and adjacent combustibles. Do not operate the insert if there is an abnormal air leakage into the unit, such as through deter

14 5. Decayed wood or low density wood has very little energy content or heating value, and will not burn satisfactorily for long periods of time. A

15 5. Light a fire at the bottom of the crumpled paper and close the door. If the fire tends to go out, momentarily hold the door slightly ajar to fa

16 3.5 Maintaining The Fire Your Century insert will work best if a thick bed of hot embers is maintained in the bottom of the firebox, and a minimum

17 Section 4.0 Maintenance 4.1 Care And Cleaning Clean the insert frequently so that soot, ash and creosote do not accumulate. Do not attempt to cl

18 4.2 Ash Removal CAUTION: Ashes can start fires, even after several days of inactivity. Never dispose of ashes in a combustible container. Remov

1 INTRODUCTION SBI INC., one of the most important wood stove and fireplace manufacturers in Canada, congratulates you on your purchase

19 Baffle Installation for CW2500 Figure 4.1 – Baffle installation & removal for CW2500 CENTRAL & REAR TUBE BAFFLE TUBE A

20 All firebrick and vermiculite baffles must be properly in place for correct burning operation. Have any damaged firebricks replaced. C

21 4.5 Secondary Air Tube Replacement (see Figure 4.5) 1. Remove cotter pin at RH end of tube. 2. Slide tube to left and lower tube end below RH

22 4.6 Fan Maintenance & Care Clean the fan air inlet louvers and squirrel cage impeller regularly. The fan should be kept clean and dust free.

23 Section 5.0 Specifications 5.1 CW2500 Insert Fuel Type Cordwood Test Standards ULC S628 (CSA B366.2) & UL 1482 residential. Maxi

24 CENTURY HEATING LIMITED WARRANTY The warranty of the manufacturer extends only to the original consumer purchaser and is not transferable. This wa

2 TABLE OF CONTENTS INTRODUCTION ...

3 CW2500 Dimensions 261316"271316"13716"13516"11 1/16"21 3/16"21 11/16"9916"738"21 11/16"

4 Section 1.0 Pre-Installation Requirements 1.1 Masonry & Zero Clearance Requirements The masonry fireplace must meet the minimum code requirem

5 NOTE: A METAL TAG IS PROVIDED AND IS TO BE FASTENED TO THE BACK WALL OF THE FIREPLACE IF THE FIREPLACE HAS BEEN MODIFIED TO ACCOMMODATE THE INSERT

6 Section 2.0 Installation 2.1 Clearances To Combustibles (Measured From Insert Body) CW2500 Sidewall (A) 12” (305 mm) Top mantle (B) 10” (255 m

7

8 2.1.1 Hearth Requirements If the non-combustible hearth is flush with the floor, then the hearth must be 16”/406mm (18”/450mm in Canada) in fro